Car Fix DIY Videos

Window roller replacement: 30 – 45 minutes ($5 / $120 / $225) PN: 9152606, Sliding block Door panel removal x70: https://youtu.be/7GUJHLJ1XnI Door panel removal 850: https://youtu.be/M5G5SKQ4P60 ————————————————- Disclaimer: https://www.youtube.com/watch?v=SLPVaRK9sDU How to search my videos: https://www.youtube.com/watch?v=gt9w-ZSxs9I Visit my Website for special tools, my wish list and other helpful information: http://www.RobertDIY.com Support Robert, become a Patron: http://www.Patreon.com/RobertDIYAfterDark/

RIP Kit Installation: 1 to 2 hours ($300 / $450) In this video I show how to replace the turbo pipping on a P80 Volvo. Some silicone piping are slightly undersized and may require that you wet the silicone with warm soapy water to get them to slide on to the pipes. Why install a […]

Wastegate Replacement: ($80 / $180 / $400) Wastegate info: https://www.youtube.com/watch?v=PXR9m-c_FuM In this video I replaced the turbo actuator / wastegate on my 15g turbo. The main reason I replaced it is because the rod was severely corroded and it could not be adjusted, to rusty. I was also hoping it was defective because I am […]

Alternator replacement: ($30 / $350 / $650) In this video I helped a buddy replace the alternator in his 2002 C70. I’m sure this process is the same for several Volvo’s between 1999 – 2004.

O2 sensor replacement: 15 to 30 minutes ($65 / $150 / $310) In this video I helped a friend replace an o2 sensor in a 1999 Mercury Villager. I’m sure this process is the same on other Villagers, Nissan Quest, etc.

In this video, I show you how to replace a Toyota key fob battery. It is a simple process, and can easily be done with a small flathead screwdriver. If your key fob for your Toyota Camry or Corolla doesn’t work, it may be because the battery is dead. I show you exactly how to […]

Easy basic. This video applies to most Volvo cars from the 80-80 era. If you have any questions, just ask! If you liked the video, rate and subscribe. /Bk

Fuel pump replacement: 2 to 3 hours ($300 / $700 / $1200) WARNING: Check the fuel pump wire connection. If bad replace it. Our new pump burned out in 3,000 miles. PN: LNC 3360CA for a connector that can be spliced in. ($25 eBay used / $135 eBay new / $185 local). I helped my […]

Steering rack replacement: 3 to 5 hours ($400 / $800 / $1700) Small seal size: In this video I helped a friend replace the steering rack on his 1998 Volvo S70. This process should be the same for all of the P80 Volvo cars from 1993 through 2000. If you need to replace the rack […]

Shift cables bushing replacement: 45 to 60 minutes ($10 / $470 / $700 In this video I repaired the manual shift cable bushings that wear out at the transmission connection linkages. This should work on Volvo cars between 1993 – 1999, Volvo 850, S70, V70 vehicles with a manual transmission.

Speaker replacement: 30 – 60 minutes ($15 / $125 / $225) In this video I show how to remove a door speaker from a Volvo S70, V70, V70 XC, etc. (P80 x70 series vehicles). This may work for other Volvo vehicles.

Rear suspension replacement: 30 to 90 minutes ($120 / $300 / $450) In this video I replaced the rear shocks and springs in my 850 R. Since my car had the Nivomats and I was not going to replace them with new Nivomats, I had to replace the springs as well.

Rear hatch latch repair: 30 to 90 minutes ($25 / $150 / $525) In this video I trouble shoot a rear hatch problem and replace a part on the latch that controls the locking mechanism. This should work on most Volvo cars built between 1992 through 2000, including the Volvo 850, V70 and V90 cars.

Fuel pump replacement info. WARNING: Check the fuel pump wire connection. If bad replace it. Our new pump burned out in 3,000 miles. PN: LNC 3360CA for a connector that can be spliced in. ($25 eBay used / $135 eBay new / $185 local). Step by step procedures: https://www.youtube.com/watch?v=FKbrNzAsuVk I helped my brother replace the […]

Door glass replacement: 30 to 60 minutes ($30 / $160 / $300) x70 Door panel removal: https://www.youtube.com/watch?v=bCmUEv8q5W4 850 Door panel removal: https://www.youtube.com/watch?v=M5G5SKQ4P60 For other door panel removals, search my YouTube channel. This video is compliments of some mean kid that busted my window out while I was visiting a friend in Little Rock, AR. Took […]

Shift lock solenoid replacement: 45 to 60 minutes ($120 / $210 / $450) In this video I show why the shift handle gets stuck in Park and you have to press the manual override button to release it. Volvo 850, S70, V70 and other Volvo cars. 850 Center console removal: https://www.youtube.com/watch?v=aqMY5BqMY84 x70 Center console removal: […]

Power steering pump replacement: 60 to 90 minutes ($50 / $150 / $325) In this video I replace the power steering pump on a 1998 Volvo S70.

Main fuse replacement: 15 – 30 minutes ($5 / $100 / $140) In this video I helped my friend replace the main 120 amp alternator fuse in the main fuse box panel of his 2003 Lexus GS 300. I’m sure this process is the same on many Lexus, Toyota and other vehicles / cars.

In this video I visited a repair shop that services Volvo cars. They share with me how they install the VVT hubs and adjust the timing for them to function properly. This will apply to many Volvo vehicles, S40, V40, S60, V70, V70XC, S80, XC90, C70, S70, etc. Timing info: https://www.youtube.com/watch?v=MPt0BZ3B_2w VVT hub seal replacement: […]

Anti sway bar replacement: 60 minutes each ($40 / $300 / $850) Rear bar torque specs: – Drivers side small bolt, 37 ft lbs plus 90 degrees – Drivers side large bolt, 48 ft lbs plus 90 degrees – Passenger side dual bolts, 37 ft lbs – Drivers side link mount, 37 ft lbs plus […]

Fuel pump replacement: 2 to 3 hours ($300 / $700 / $1200) I helped my brother replace the fuel pump in his 2003 Jaguar XJ8, X308 series. The hardest part of the job is getting the fuel lines disconnected. There are a few other parts that are hard as well, mainly things that can cause […]

Power steering rack replacement: 2 to 3 hours ($150 / $500 / $1200) In this video I replaced the power steering rack and lines in my Volvo 850 Turbo while doing a manual transmission conversion. This video should have enough information to guide you through the process on your P80 vehicle.

Timing belt replacement: 3 to 5 hours ($200 / $800 / $1,100) Crank/harmonic balancer bolt is 36mm. This is the process if removing the harmonic balancer. Seal leaks, VVT, front cam seals, etc.: https://www.youtube.com/watch?v=hjZFY-1x1Xk A place to purchase the cam locking tool: https://swedishcarparts.com/parts/754-volvo-850-s70-s40-v70-s80-s60-960-xc90-timing-belt-camshaft-tool-made-in-usa-9995452s In this video I replaced the timing belt on a 2005 S60 […]

Head Installation: 4 to 6 Hours. ($800 / $2,800 / $5,300) Website tutorial (written instructions): http://www.atthetipwebs.com/technologyinstructions/head_gasket.htm In this video I installed the head on a Volvo with an inline 5 motor. This directly applies to the Volvo 850 and Volvo S70, V70 cars. You would have had the head removed for the following reasons: – […]

In this video I share a some information that I have learned about instrument cluster issues with my Volvo 740 wagon. I believe this information will apply to other Volvo vehicles, especially the red block ones. How to remove the instrument cluster, 740: https://www.youtube.com/watch?v=khVod5RHjv8 How to remove the instrument cluster, 940: https://www.youtube.com/watch?v=k5m3H6Z_aDQ

Front cam seal replacement: 1 to 2 hours ($25 / $115 / $425) In this video I replaced the front cam seal on a 1998 Volvo S70. This will be the same for most Volvo cars with the non-VVT hub.

Hood cable replacement: 30 to 60 minutes ($15 / $120 / $200) In this video I show how to inspect and replace the hood release cable for the Volvo 850, S70, V70, etc.

SAS Modification: 60 to 90 minutes ($5 / $520 / $625) In this video I show you how to do a modification to the car to clear the CEL error code P0410. This fix is for Volvo 850, S70, V70, XC70, C70, V70R, etc. You need a 200v-1A Silicon Diode.

In this video I show how to remove and install the air filter box on a Volvo 850, S70, V70, V70 XC, etc. You may need to remove it to access other things in the engine compartment.

Headlight assembly repair: ($10 / $210 / $325) In this video I show how you can replace the headlight assembly reflector on a Volvo S70, V70, 850, etc. Some people have removed the reflector and painted them with high temperature, REFLECTIVE chrome paint. You can replace the assembly, the reflector, or try to paint it. […]

Door Latch Repair: 45 to 60 minutes ($10 / $290 / $390) Door panel removal: https://www.youtube.com/watch?v=bCmUEv8q5W4 Panel repair: https://www.youtube.com/watch?v=7GUJHLJ1XnI Not sure if this applies to other Volvo’s but the ’98 – ’00 Volvo S70, V70, XC70, etc., have latches that get old and will not unlock with the remotes and power door switch. This video […]

Turbo drain leak: 30 to 60 minutes ($10 / $110 / $160) In this video I replaced the seals on the turbo drain tube on a Volvo S70 GLT. This process is the same on several Volvo turbocharged cars, 850, XC70, etc.

Battery replacement: 10 to 20 minutes ($50 / $125 / $325) In this video I show how to replace a battery in the Volvo 850, V70, S70, and many other Volvo cars. Radio code: https://www.youtube.com/watch?v=HvMhTpqY-Vk Used battery purchase: https://www.youtube.com/watch?v=lnATaEnHaXE How to properly jump start your car: https://www.youtube.com/watch?v=dOISTPXvVlE Bad battery or alternator: https://www.youtube.com/watch?v=_1q40V-BPQc