This is a 2008 Mercedes Benz E-350 with a no-start condition. Fuel pump failure on a California emissions PZEV sealed system. This video shows you how to diagnose and replace the fuel tank.
Mercedes Benz No Start Diagnosis and Fix
18,773
Like
Save
){kind=link}
- Tags:
Benz, diagnosis, Mercedes, Start
- Categories: Mercedes-Benz
Comments
Comments are disabled for this post.
oh boy I got lucky, I have a 2008 E-350 with 130k miles the same PZEV sealed fuel pump and was covered by dealer the warranty will expire on November 30th of 2021 so if you have one you better get in to Benz and they will change it under Emission warranty Good luck.
wow you just saved my A. I will not buy ANYTHING from Cali.
I watch all your vids…. the best.
If the fuel pump don’t turn off after u turn off the car what can it be
Could it be that it needs to be program the key I just replace the battery and it didn’t start
you are the man., 2500 non serviceable, that's crazy, great video, very thorough. Thanks
Hi, I have 2001 W210 E320 wagon. The torque specs are the same ? 115 Nm for main two screws ?
..Good job.
it must be a 2008 thing i have a 2011 and mine are serviceable.
Hi I have the same tank and have power to relay and pump . But no power to the sending unit when turning the key.when I jump the 3and 5 pins on relay board the pump comes on but don't pump fuel to hose and sounds like the pump is pumping fuel back in to the tank. But y don't the pump come on when key is turn is this a ecm.or fuel shut off.
I sprayed carb cleaner & it starts right up. Then It Dies 3-7 seconds later. I have a new fuel pump so what should I replace/ swap out?
You don't have to replace tank!!! I installed an exterior fuel pump in trunk, tapped bottom of tank, ran fuel line thru chassis to tank and then installed small fuel filter after pump and ran line next to back seat and installed a bulkhead fitting to top of tank so I could install fuel line to fuel filter which I had purchased online. I disconnected line from burned out pump and installed mine. Been running it for one week so far without problem. Lastly, the reason the pumps fail on these stupid tanks is my original fuel filter was completely clogged thus burning out the pump. Idiots at MB don't tell you either in maintenance book or owners manual to change out fuel filter which is very easy as you know. If you want more info I could post a video showing you what I did. My email is markso100@yahoo.com. Total cost less then $400 an a couple of hours of labor.
Hey there sir I have the exact problem but short with money what is the best option for me to do with the car ? If I was to sell it like this how much best can I get from it
I sprayed carb cleaner but did not crank.code of crank shaft sensor is reading.dont hear pump engaging at all.could the crank sensor make the pump not engage.please call me at 2516480719..tim