Car Fix DIY Videos

Combo Six Foot Aluminum Storage Box and Eight Foot Aluminum Dump Body with Ten Foot Detachable Pull Out Walk Ramp on Isuzu 19500 GVW NRR Diesel Crew Cab. Walk Around
Review of Storage Box, Dump Body, Detachable Multi Location Walk Ramp and Isuzu NRR Crew Cab by Michael Olden of Lee-Smith. Contact Michael Olden 423-618-3323 or email molden@lee-smith.com to discuss this specification for your company.

A viewer referred to this as sick. But very healthy for so many industries. The ordering client is in the pavers and hardscape industry. They needed ample room for compactors and table saws. With the walk ramp the can easily stow all these without breaking their back – higher safety. Additionally they can set four wheel barrows if needed. The cab can seat up to seven so if they need to kick it into high gear at a job they can add those extra men (or women). Also because of the latching the ramp is usable anywhere along the rear, or width of the cross I box. If I can build a standard or crew cab for you let me know!!

The Truck – Isuzu NRR
19500 GVW 23950 GCW
Diesel 4H Engine 215 hp 452 Torque
Aisin Six Speed Double Overdrive Transmission w O/D off switch
Front and rear Disc Brakes
7300 Front
14500 Rear
Three year unlimited mileage base warranty from stem to stern (except PM, Battery, Lamps)
Available engine, transmission, rear axle plus the after treatment system warranty – That’s five years to 200,000 Miles from in service.

Body:
Storage Box
All aluminum
Six foot long (72 inch outside length)
Five feet tall (60 inch floor to roof)
Full access door openings
Barn door Driver side
Barn door passenger side
Full width latching for Ramp
Wheelbarrow rack
Six inch raised perimeter
Roof pitched to mitigate water

Dump body
All aluminum
Magnetic controller.
Electric over hydraulic hoist
Dedicated subframe
Eight foot long (96 inch)
Eight foot wide (96 inch)
Double walled
Interior aluminum post on 16 inch centers
Smooth Exterior Skin
Barn Door Rear – Camber Latch and Secondary Pin
Full width latching for ramp

RAMP – Detachable
All aluminum
Light Weight
Ten foot ramp
Twenty-four inch width
Smooth surface with Anti Skid Tape Tread
Independent Storage

Where does that go?
The pull out ramp storage is a ten foot ramp on an eight foot body.
Now that’s a trick.

Towing
GI pintle hitch
Safety rings
Electric connector
Electronic brake controller

The body comes with a one year warranty on the labor and the hoist.
And a five year structural warranty on the aluminum box and the dump bin.

Quite a body, when you’re take a look at volume versus length.

Isuzu Crew cab comes standard 7 man seating, tilt and telescopic steering column, odometer / fuel level check, the oil check, in cab easy access oil check, front engine compartment access (oil fill, radiator fill and most of the right side of the engine and belts)
power power door locks, Power windows Front and Rear (with driver remote control to rear), Cruise control, Multi-function left side switch (controls your cruise set, resume, your headlamps, your flash to pass, your brights), Multi-function right side switch (controls engine exhaust brake and windshield wiper with intermittent and windshield washer fluid), in cab translucent brake fluid reservior, standard cup holders, big Gulp holders, trash hook, two power points, AM/FM/CD with USB radio allows handsfree operation, remote microphone, manual regeneration request switch

Isuzu Safety:
Headlamps broadcast light into turn path when selecting left or right directional
Oversized West Coast Mirrors with Convex
Memory position West Coast Mirror Arms.
Aerodynamic West Coast Mirror Casing
Protruding side directional lamps for increased visibility

0:00 Introduction 8 foot dump 6 foot Box Isuzu NRR
0:19 Isuzu NRR Exterior and Warranty Chassis and Body
1:49 Storage I-Box Crossbox Aluminum Six Foot
2:30 Dump Body Eight Foot Aluminum
3:01 Walk Ramp to Body Benefits
3:30 Pull Out Ramp Storage 10 foot
3:52 GI Pintle Hitch – Trailering
4:07 Ramp Benefits Demonstration
5:20 Top of Storage Box and Access
5:46 Dump Body Controller and Operation
6:31 Ramp Storage Rack Close Up
6:49 Isuzu NRR Interior Switches, Components
7:24 Demonstration to Access Engine on Crew Cab
9:09 How To Request Manual Regeneration on Isuzu Diesel Engine
10:11 Conclusion on Walk Around
10:32 Isuzu NRR Video Only Eight Foot Dump Six Foot Storage Box
11:30 Final Sign Off